Possible malfunctions of the diesel fuel system Before troubleshooting based on this table, you should check whether the following conditions are met: no error in operation; fuel is in the tank, the starter...
Dehydration and replacement of the fuel filter In order for the car engine to work flawlessly, every 500 km it is necessary to remove moisture from the fuel filter and replace this fuel filter every 300 km....
Checking and adjusting the idle speed To adjust the idle speed, a tachometer designed for a diesel engine is used, which uses the principle of a photocell. This device must be connected to the W...
Checking and adjusting the maximum speed To regulate the maximum speed, use a tachometer designed for diesel engines, which uses the principle of a photocell. On the front shoulder of the crankshaft...
Gas drive installation Fully depress the gas pedal. Next, without removing your leg, install the gas drive by re-docking the stop on the bracket (arrow), so that the injection lever...
Checking glow plugs Remove the connecting cable and current bar from the glow plugs. Connect a test bulb to the battery terminal and connect it in series to each of the spark...
Removal and installation of nozzles Defective injectors can cause severe engine knocking and bearing failures. In this case, it is necessary to start the engine at idle and loosen the union nuts...
Checking the start of fuel supply Checking without removing the engine is described below. The test requires a dial indicator with the appropriate adapter to screw into the pump. Install...