Rechargeable battery (AB) The installed battery with a voltage of 12 V has 6 cans (cells), which consist of positive and negative plates that are in a solution of sulfuric acid. The...
Battery checks Electrolyte level As already mentioned, AB is unattended. It is filled with a solution of sulfuric acid and distilled water. Because some of the water may...
Charging System Precautions Before carrying out any work on the charging system, read the following precautions. Never disconnect the battery or voltage regulator while the engine and...
Removal and installation of the generator Disconnect the negative wire from the battery and move it away so that it does not accidentally connect back. Remove V-belt. Disconnect the plug from the back...
Generator repair The generator can be considered as unattended. Only after a very long run it may happen that it will be necessary to replace the brushes. Before carrying out...
Battery Charging System Malfunctions Listed below are some malfunctions, their possible causes and solutions that can help with diagnosis. The AB charge control lamp does not light up when the...
Starter Components of a starter 1 Magnetic starter 2 Terminal 30 (battery connection) 3 Terminal 50 (to the ignition system) 4 Drive gear 5 Starter Location of the...
Starter check To check the starter with battery voltage, you need to connect terminals 30 (large terminal) and 50 (small wire next to large terminal) using a wire with a...
Removal and installation of a starter Disconnect the negative wire from the battery. Remove the noise-proof plastic in the lower part of the engine compartment by loosening the quick-release...
Disassembly and assembly of the starter As in the case of the generator, self-repair of the starter is not recommended, because. before installing the starter back on the vehicle, it is necessary to...