Vehicle steering Audi 100 C3, petrol
Detailed technical specifications of the steering system
Depending on the configuration, the cars were equipped with mechanical steering or power steering. Steering with a rack and pinion mechanism with spiral teeth...
Depending on the configuration, the cars were equipped with mechanical steering or power steering. Steering with a rack and pinion mechanism with spiral teeth...
Steering shaft parts
Steering shaft parts: 1 - upper shaft; 2 - lower shaft (mechanical steering); 3 - lower shaft (power steering); 4 - shaft support flange; 5 - shaft support; 6...
Steering shaft parts: 1 - upper shaft; 2 - lower shaft (mechanical steering); 3 - lower shaft (power steering); 4 - shaft support flange; 5 - shaft support; 6...
Steering Parts
Steering parts: A - mechanical steering; B - power steering 1 - steering gear housing; 2 - protective cover; 3 - right steering rod; 4 - steering shock...
Steering parts: A - mechanical steering; B - power steering 1 - steering gear housing; 2 - protective cover; 3 - right steering rod; 4 - steering shock...
Removal and installation the steering gear
Note: The steering mechanism without power steering cannot be repaired and must be replaced entirely. Removal Remove the windshield washer reservoir. Raise the...
Note: The steering mechanism without power steering cannot be repaired and must be replaced entirely. Removal Remove the windshield washer reservoir. Raise the...
Adjusting the steering wheel free play
The steering wheel free play is adjusted using a self-locking adjusting screw. Check while driving whether the steering wheel returns to the straight-ahead...
The steering wheel free play is adjusted using a self-locking adjusting screw. Check while driving whether the steering wheel returns to the straight-ahead...
Removal and installation the steering shaft
Removal Disconnect the wires from the battery terminals. Remove the horn switch trim panel manually. Loosen the steering wheel mounting nut. Remove the...
Removal Disconnect the wires from the battery terminals. Remove the horn switch trim panel manually. Loosen the steering wheel mounting nut. Remove the...
Steering shaft with passive safety system «PROCON-TEN»
Steering parts for vehicles with the PROCON-TEN passive safety system: 1 - drive gear shaft; 2 - Instrument panel bracket; 3 - steering shaft; 4 - cable; 5 -...
Steering parts for vehicles with the PROCON-TEN passive safety system: 1 - drive gear shaft; 2 - Instrument panel bracket; 3 - steering shaft; 4 - cable; 5 -...
Disassembly and assembly of the steering mechanism
Disassembly Warning: When disassembling and assembling the steering gear, ensure that the work area is perfectly clean and that no dust, dirt or foreign matter...
Disassembly Warning: When disassembling and assembling the steering gear, ensure that the work area is perfectly clean and that no dust, dirt or foreign matter...
Checking the tightness of the power steering system
Warning: Check the hydraulic booster system regularly for leaks, and do not allow the fluid level in the reservoir to drop. Turn the steering wheel from one...
Warning: Check the hydraulic booster system regularly for leaks, and do not allow the fluid level in the reservoir to drop. Turn the steering wheel from one...
Checking the power steering pump discharge pressure
Disconnect the high pressure hose from the pump (steering contour) and connect the pressure gauge hose instead. Start the engine. Using a pressure gauge,...
Disconnect the high pressure hose from the pump (steering contour) and connect the pressure gauge hose instead. Start the engine. Using a pressure gauge,...
Filling the power steering system
Note: Do not reuse oil that has been drained from the system. Fill the power steering system reservoir with oil up to the "MAX" mark. Raise the front of the...
Note: Do not reuse oil that has been drained from the system. Fill the power steering system reservoir with oil up to the "MAX" mark. Raise the front of the...
Adjusting the tension of the power steering pump drive belt
The normal deflection of the belt when pressed with the thumb should be about 10 mm. Cars with 4-cylinder engines The belt tension is adjusted by installing...
The normal deflection of the belt when pressed with the thumb should be about 10 mm. Cars with 4-cylinder engines The belt tension is adjusted by installing...
This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian
Similar sections of other Audi car models:
Chassis: Steering Audi 80 B2 (1979-1986)
Chassis: Steering Audi A3 Type 8L (1996-2003)
Chassis: Steering system Audi A4 B8 (2007-2015)
Chassis: Steering Audi A6 C4 (1994-1997)
Chassis: Steering Audi A8 D2 (1994-2002)
Chassis: Steering system Audi Q7 Typ 4L (2005-2015, diesel)
Chassis: Steering Audi A2 (1999-2005)
Chassis: Steering Audi 80 B2 (1979-1986)
Chassis: Steering Audi A3 Type 8L (1996-2003)
Chassis: Steering system Audi A4 B8 (2007-2015)
Chassis: Steering Audi A6 C4 (1994-1997)
Chassis: Steering Audi A8 D2 (1994-2002)
Chassis: Steering system Audi Q7 Typ 4L (2005-2015, diesel)
Chassis: Steering Audi A2 (1999-2005)
Share information:
- General information
- User manual
- Power unit
- Engine repair
- Ignition system
- Fuel system (gasoline)
- Fuel system (diesel)
- Lubrication system
- Cooling system
- Exhaust system
- Transmission
- Clutch
- Car gearbox
- Drive shafts
- Chassis
- Car suspension
- Steering
- Wheels and tires
- Brake system
- Body
- Ventilation and heating
- Body repair
- Electrical equipment
- Power devices
- Lighting and appliances
- Electrical circuits
- General information
- Operation and maintenance
- Power unit
- Engine repair
- Exhaust system
- Cooling system
- Supply system
- Air filter
- Mono-Motronic injection system
- Digifant injection system
- KE-III-Jetronic and KE-Motronic
- MPI and MPFI injection system
- Transmission
- Clutch
- Car gearbox
- Chassis
- Suspension and steering
- Brake system
- Wheels and tires
- Body
- Exterior
- Interior
- Electrical equipment
- Fuses and relays
- Power devices
- Ignition system
- Lighting and signaling
- Equipment and devices
- Electrical circuits
- General information
- User manual
- Maintenance
- Specifications
- Power unit
- Engines 4-cylinder
- Engines 5-cylinder
- Diesel engine
- Cooling system
- Power system (carburetor)
- Power system (injector)
- Fuel system (diesel)
- Transistor ignition system
- Electronic ignition system
- Transmission
- Clutch
- 4 speed gearbox 014
- 5 speed gearbox 013 and 093
- 5 speed gearbox 016 and 012
- Shift mechanism KP 016
- Automatic transmission
- Front wheel drive
- Chassis
- Front suspension
- Rear suspension
- Steering
- Brake system
- Body
- Body elements
- Electrical equipment
- Lighting and appliances
- Power devices
- Electrical circuits
- General information
- Maintenance and operation
- 4 cylinder engine
- Engine repair
- Cooling and lubrication system
- Supply system
- Ignition system
- 5 cylinder engine
- Engine repair
- Cooling and lubrication system
- Supply system
- Ignition system
- Transmission
- Clutch and drive shafts
- 4 speed gearbox 014
- 5 speed gearbox 013 and 093
- 5 speed gearbox 016 and 012
- Automatic gearbox
- Chassis
- Steering
- Front suspension
- Rear suspension
- Brake system
- Body
- Body elements
- Doors, locks and windows
- Body repair
- Electrical equipment
- Equipment and devices
- Power devices
- Electrical circuits
- General information
- User manual
- Maintenance
- Troubleshooting
- Power unit
- Engine in a car
- Engine removed
- Cooling system
- Fuel system
- Exhaust system
- Starting and charging
- Preheating
- Transmission
- Clutch
- Mechanical gearbox
- Automatic gearbox
- Drive shafts
- Chassis
- Brake system
- Suspension
- Steering
- Body
- Exterior
- Interior
- Electrical equipment
- Equipment and devices
- Electrical circuits