Vehicle power devices Audi 100 C3
Audi 100 C3 powertrain repair. This guide describes the alternator, including its removal and installation, disassembly and assembly, testing, inspection, and troubleshooting, as well as adjusting the drive belt tension. It also covers the starter, including its removal and installation, disassembly and assembly, testing, inspection, and troubleshooting. This guide includes essential procedures and recommendations. Illustrations are provided for ease of use. Common faults are highlighted. Following the instructions will ensure high-quality repairs. Tightening torques are provided, along with electrical parameters. Brushes and the regulator are discussed in detail. Diagnostic tips are also provided.
Generator device
Generator 1 - screw; 2 - voltage regulator; 3 - brushes; 4 - cover from the contact ring side; 5 - rectifier block; 6 - screw; 7 - stator; 8 - tension bolt; 9...
Generator 1 - screw; 2 - voltage regulator; 3 - brushes; 4 - cover from the contact ring side; 5 - rectifier block; 6 - screw; 7 - stator; 8 - tension bolt; 9...
Removal and installation the generator
Execution order 1. Disconnect the wire from the negative terminal of the battery. 2. Disconnect the electrical wires from the generator terminals, having...
Execution order 1. Disconnect the wire from the negative terminal of the battery. 2. Disconnect the electrical wires from the generator terminals, having...
Disassembly and assembly of the generator
Execution order 1. Clean the generator from dirt and dust. 2. Unscrew the mounting screws and remove the voltage regulator with the brush holder. 3. Loosen the...
Execution order 1. Clean the generator from dirt and dust. 2. Unscrew the mounting screws and remove the voltage regulator with the brush holder. 3. Loosen the...
Checking, inspecting and troubleshooting generator parts
Execution order 1. Inspect the contact rings. If they have burrs, scratches, marks, traces of wear from brushes, etc., the rings must be ground. If the damage...
Execution order 1. Inspect the contact rings. If they have burrs, scratches, marks, traces of wear from brushes, etc., the rings must be ground. If the damage...
Adjusting the alternator drive belt tension
Execution order 1. Loosen the bolts securing the generator to the bracket, the generator adjusting bar, and the generator to the adjusting bar. 2. Rotate the...
Execution order 1. Loosen the bolts securing the generator to the bracket, the generator adjusting bar, and the generator to the adjusting bar. 2. Rotate the...
Starter device
Starter Bosch 0.95 kW 1 - nut; 2 - support plate; 3 - screw; 4 - lid; 5 - gasket; 6 - retaining ring; 7 - washer; 8 - tension bolt; 9 - bearing; 10 - cover...
Starter Bosch 0.95 kW 1 - nut; 2 - support plate; 3 - screw; 4 - lid; 5 - gasket; 6 - retaining ring; 7 - washer; 8 - tension bolt; 9 - bearing; 10 - cover...
Removal and installation the starter
Execution order 1. Disconnect the wire from the negative terminal of the battery. 2. Loosen the nuts and disconnect the electrical wires from the starter...
Execution order 1. Disconnect the wire from the negative terminal of the battery. 2. Loosen the nuts and disconnect the electrical wires from the starter...
Disassembling and assembling the starter
Execution order 1. Loosen the nuts. 2. Remove the support plate. 3. Unscrew two screws and remove the cover with the gasket. 4. Remove the retaining ring with...
Execution order 1. Loosen the nuts. 2. Remove the support plate. 3. Unscrew two screws and remove the cover with the gasket. 4. Remove the retaining ring with...
Checking, inspecting and troubleshooting starter parts
Execution order 1. Clean all starter parts. 2. Check the condition of the stator winding. Apply alternating current of 220 V to one contact of the test lamp....
Execution order 1. Clean all starter parts. 2. Check the condition of the stator winding. Apply alternating current of 220 V to one contact of the test lamp....
This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian
Similar sections of other Audi car models
Electrical equipment: Power devices Audi 80 B3 (1986-1991)
Electrical equipment: Power devices Audi A3 Type 8L (1996-2003)
Electrical equipment: Power devices Audi A4 B5 (1994-2001)
Electrical equipment: Power devices Audi A6 C5 Allroad (1999-2005)
Electrical equipment: Power devices Audi Q5 Type 8R (2008-2017)
Electrical equipment: Power devices Audi A2 (1999-2005)
Share information:
- General information
- User manual
- Power unit
- Engine repair
- Ignition system
- Fuel system (gasoline)
- Fuel system (diesel)
- Lubrication system
- Cooling system
- Exhaust system
- Transmission
- Clutch
- Car gearbox
- Drive shafts
- Chassis
- Car suspension
- Steering
- Wheels and tires
- Brake system
- Body
- Ventilation and heating
- Body repair
- Electrical equipment
- Power devices
- Lighting and appliances
- Electrical circuits
- General information
- Operation and maintenance
- Power unit
- Engine repair
- Exhaust system
- Cooling system
- Supply system
- Air filter
- Mono-Motronic injection system
- Digifant injection system
- KE-III-Jetronic and KE-Motronic
- MPI and MPFI injection system
- Transmission
- Clutch
- Car gearbox
- Chassis
- Suspension and steering
- Brake system
- Wheels and tires
- Body
- Exterior
- Interior
- Electrical equipment
- Fuses and relays
- Power devices
- Ignition system
- Lighting and signaling
- Equipment and devices
- Electrical circuits
- General information
- User manual
- Maintenance
- Specifications
- Power unit
- Engines 4-cylinder
- Engines 5-cylinder
- Diesel engine
- Cooling system
- Power system (carburetor)
- Power system (injector)
- Fuel system (diesel)
- Transistor ignition system
- Electronic ignition system
- Transmission
- Clutch
- 4 speed gearbox 014
- 5 speed gearbox 013 and 093
- 5 speed gearbox 016 and 012
- Shift mechanism KP 016
- Automatic transmission
- Front wheel drive
- Chassis
- Front suspension
- Rear suspension
- Steering
- Brake system
- Body
- Body elements
- Electrical equipment
- Lighting and appliances
- Power devices
- Electrical circuits
- General information
- Maintenance and operation
- 4 cylinder engine
- Engine repair
- Cooling and lubrication system
- Supply system
- Ignition system
- 5 cylinder engine
- Engine repair
- Cooling and lubrication system
- Supply system
- Ignition system
- Transmission
- Clutch and drive shafts
- 4 speed gearbox 014
- 5 speed gearbox 013 and 093
- 5 speed gearbox 016 and 012
- Automatic gearbox
- Chassis
- Steering
- Front suspension
- Rear suspension
- Brake system
- Body
- Body elements
- Doors, locks and windows
- Body repair
- Electrical equipment
- Equipment and devices
- Power devices
- Electrical circuits
- General information
- User manual
- Maintenance
- Troubleshooting
- Power unit
- Engine in a car
- Engine removed
- Cooling system
- Fuel system
- Exhaust system
- Starting and charging
- Preheating
- Transmission
- Clutch
- Mechanical gearbox
- Automatic gearbox
- Drive shafts
- Chassis
- Brake system
- Suspension
- Steering
- Body
- Exterior
- Interior
- Electrical equipment
- Equipment and devices
- Electrical circuits