Vehicle steering Audi 80 B3, petrol

Steering wheel — removal and installation
1. Remove the horn button from the center of the steering wheel by first releasing the top and then the base of the button (photo). Do this carefully,...

Steering column — removal, overhaul and installation
1. Disconnect the negative battery cable. 2. Remove the trim panel covering the steering column. 3. Remove the steering wheel as described in Chapter 12 . 4....

Steering rod — removal and installation
1. Apply the handbrake, jack up the front of the car and support it on axle stands. Remove the front wheel on the corresponding side of the car. 2. Remove the...

Steering gear — removal and installation
Note: Repair of the steering gear is not possible. If the unit is excessively worn, the action will be weak and the steering will transmit a large amount of...

Steering damper — inspection, removal and installation
1. The steering damper is fitted on direct acting steering models and is connected between the steering rod mounting member and the mounting protrusion on the...

Steering Gear Guards — Replacement
1. Loosen and remove the bolts securing the tie rod mounting plate to the steering rack. Support the plate above the rack using a block. 2. Remove the covers...

Steering gear (mechanical) — adjustment
1. If there is any inappropriate play in the steering gear causing noise or rattling, the steering gear must be adjusted as follows. An assistant is required...

Power Steering System — Draining, Filling and Bleeding Fluid
Draining and filling liquid 1. Place a suitable container under the feed tank, then disconnect the pump feed hose, drain the liquid from the tank. 2. Place a...

Power Steering System — Leak Test
1. With the engine running, turn the steering wheel to the maximum turning angle in one direction and lock it in this position to create maximum pressure in...

Power steering pump — removal, overhaul and installation
1. Where applicable, unscrew and remove the radiator cooling fan shroud. 2. Loosen the pump adjusting and mounting bolts (photo), turn the pump toward the...

Wheel installation — checking and adjustment
1. Accurate wheel alignment is essential for good steering and slow tire wear. Alignment values are given in Specifications and can be accurately checked with...

Wheels and Tires — General Precautions and Maintenance
Wheels and tires should not cause any real problems during operation if you carefully monitor their condition. The following points should be noted. Check and...

Troubleshooting suspension and steering
Excessive play in steering The steering gear is worn out Worn out tie rod end ball joints The steering rod bushings are worn out Incorrect rack adjustment Worn...

This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian

Салон джили официальный дилер в Москве

Share information:

80(B4, 1991-1996)

80(B3, 1986-1991)

80(B3, 1986-1991, petrol)

80(B2, 1979-1986)