Manual gearbox «0B2» of cars Audi A4 B8
Checkpoint markings and location at the checkpoint
Location at the checkpoint "Strelka A". Mechanical gearbox 0B1/2. "Arrow B". Letter designation and production date. "Strelka S". Letter designation and...
Location at the checkpoint "Strelka A". Mechanical gearbox 0B1/2. "Arrow B". Letter designation and production date. "Strelka S". Letter designation and...
Clutch Module to Flywheel Disc Tightening Sequence (4- and 6-Cylinder Engines)
Use new bolts. Tighten the bolts with a 16 mm ring spanner "VAG1332/14". Activate the el. mechanical parking brake or hold the driveshaft using the "T10172"...
Use new bolts. Tighten the bolts with a 16 mm ring spanner "VAG1332/14". Activate the el. mechanical parking brake or hold the driveshaft using the "T10172"...
Clutch — removal and installation
Removal and installation the clutch module Remove the gearbox and secure it with strap "1" to the gearbox mount "T40173." To prevent oil leakage after removing...
Removal and installation the clutch module Remove the gearbox and secure it with strap "1" to the gearbox mount "T40173." To prevent oil leakage after removing...
Gear shift mechanism — removal and installation
Gear shift mechanism "Arrow A". Switching procedure "Arrow B". Movement of Choice 1. Connecting rod. 2. Pusher rod. 3. Shift rod. 4. Gear shift lever....
Gear shift mechanism "Arrow A". Switching procedure "Arrow B". Movement of Choice 1. Connecting rod. 2. Pusher rod. 3. Shift rod. 4. Gear shift lever....
Removal the gearbox — vehicles with a 1.8 l TFSI engine
Turn off the ignition. Disconnect the battery. Carefully remove the motor cover. compartment in the "direction of the arrow" with the mounting bolts. Do not...
Turn off the ignition. Disconnect the battery. Carefully remove the motor cover. compartment in the "direction of the arrow" with the mounting bolts. Do not...
Gearbox installation — cars with 1.8 l TFSI engine
Bolts tightened at the tightening angle should be replaced. Aluminum engine-to-manual transmission mounting bolts may be reused. Replace the self-locking nuts...
Bolts tightened at the tightening angle should be replaced. Aluminum engine-to-manual transmission mounting bolts may be reused. Replace the self-locking nuts...
Gearbox removal — vehicles with a 4-cylinder diesel engine
You need to proceed as follows. Set the front wheels to the straight-ahead position. Turn off the ignition. Disconnect the battery. Carefully remove the engine...
You need to proceed as follows. Set the front wheels to the straight-ahead position. Turn off the ignition. Disconnect the battery. Carefully remove the engine...
Gearbox installation for vehicles with a 4-cylinder diesel engine
Bolts tightened at the tightening angle should be replaced. Aluminum engine-to-manual transmission mounting bolts may be reused. Replace the self-locking nuts...
Bolts tightened at the tightening angle should be replaced. Aluminum engine-to-manual transmission mounting bolts may be reused. Replace the self-locking nuts...
Removal the gearbox — vehicles with a 3.2 l FSI engine
Switch off the ignition. Disconnect the battery. Remove the rear engine cover "arrows". Remove the front wheels: right and left. Remove the sound insulation on...
Switch off the ignition. Disconnect the battery. Remove the rear engine cover "arrows". Remove the front wheels: right and left. Remove the sound insulation on...
Gearbox installation — cars with a 3.2 L FSI engine
Bolts tightened at the tightening angle should be replaced. Aluminum engine-to-manual transmission mounting bolts may be reused. Replace the self-locking nuts...
Bolts tightened at the tightening angle should be replaced. Aluminum engine-to-manual transmission mounting bolts may be reused. Replace the self-locking nuts...
Shaft sealing cuffs for gearboxes
Shaft sealing cuffs for gearboxes The sealing rings for shafts "A" and "B" are replaced only with the gearbox removed. The sealing rings for shafts "C", "D",...
Shaft sealing cuffs for gearboxes The sealing rings for shafts "A" and "B" are replaced only with the gearbox removed. The sealing rings for shafts "C", "D",...
Removal and installation the left shaft with flange, clutch module, axle shaft, shift shaft and gearbox cover
Removal and installation the left shaft with flange, clutch module, axle shaft, shift shaft and gearbox cover 1. Clutch module. 2. Clutch release lever with...
Removal and installation the left shaft with flange, clutch module, axle shaft, shift shaft and gearbox cover 1. Clutch module. 2. Clutch release lever with...
Removal and installation the differential
The differential can be removed and installed without dismantling the shift mechanism, input shaft, output shaft, axle shaft/pinion, and transmission cover....
The differential can be removed and installed without dismantling the shift mechanism, input shaft, output shaft, axle shaft/pinion, and transmission cover....
This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian
Similar sections of other Audi car models:
Transmission: Manual gearbox 0B2 Audi Q5 Type 8R (2008-2017)
Transmission: Manual gearbox 0B2 Audi Q5 Type 8R (2008-2017)
Share information:
- General information
- Operating instructions
- Power unit
- Petrol engines 1.8 l
- Petrol engines 1.8/2.0 l
- Petrol engines 3.0 l
- Petrol engines 3.2 l
- Fuel system (petrol)
- Diesel engines 2.0 l (CA*)
- Diesel engines 2.0 l (CJCB)
- Diesel engines 2.7/3.0 l
- Diesel engines 3.0 l
- Fuel system (diesel)
- Transmission
- Manual gearbox 0B1
- Manual gearbox 0B2
- Manual gearbox 0B3
- Manual gearbox 0B4
- Automatic transmission 0B5
- Automatic transmission 0B6
- Automatic transmission 0AW
- All-wheel drive system
- Chassis
- Front suspension
- Rear suspension
- Brake system
- Steering system
- Body
- Exterior
- Interior
- Seats
- Doors, locks and windows
- Security system
- Heating and air conditioning
- Electrical equipment
- Audio system
- Power devices
- Equipment and devices
- Lighting and lamps
- Electrical circuits
- General information
- Introduction to manual
- Troubleshooting
- Operating instructions
- Maintenance
- Power unit
- Petrol engines 2.0 (ALT)
- Petrol engines 2.0 (TFSI)
- Petrol engines 1.8 (MPI)
- Diesel engines
- Cooling system
- Air conditioner
- Fuel and exhaust system
- Ignition system
- Starting and charging
- Transmission
- Clutch
- Manual gearbox
- Automatic gearbox
- Drive shafts
- Chassis
- Brake system
- Front suspension
- Rear suspension
- Steering
- Body
- Exterior
- Interior
- Electrical equipment
- Equipment and devices
- Lighting and signaling
- Windscreen wipers and washers
- Electrical diagrams
- Electrical diagrams (since 2007)
- General information
- Vehicle Description
- User manual
- Maintenance
- Power unit
- Gasoline engine
- Diesel engine
- Lubrication system
- Cooling system
- Supply system
- Injection system
- Exhaust system
- Ignition and control
- Transmission
- Gear box
- Clutch and drive shafts
- Chassis
- Brake system
- Car suspension
- Steering
- Body
- Heating and ventilation
- Exterior (external elements)
- Interior (internal elements)
- Electrical equipment
- Power devices
- Lighting and appliances
- Electrical circuits
- General information
- Introduction to the guide
- Car care
- Power unit
- Engine repair
- Lubrication system
- Cooling system
- Injection and control system
- Ignition system
- Power and exhaust system
- Transmission
- Clutch and drive shafts
- Car gearbox
- Chassis
- Suspension and wheels
- Steering
- Brake system
- Body
- Interior
- Exterior
- Electrical equipment
- Equipment and devices
- Lighting and signaling
- Power devices
- Electrical circuits
- General information
- Introduction to the guide
- Car care
- Maintenance (gasoline)
- Maintenance (diesel)
- Power unit
- Gasoline engines
- Diesel engines
- Engine overhaul
- Cooling system
- Fuel injection (gasoline)
- Fuel system (diesel)
- Exhaust system
- Ignition system
- Transmission
- Clutch
- Mechanical gearbox
- Automatic gearbox
- Drive shafts
- Chassis
- Brake system
- Car suspension
- Steering
- Body
- Exterior
- Interior
- Doors, locks and windows
- Heating and ventilation
- Electrical equipment
- Power devices
- Equipment and devices
- Electrical circuits
- General information
- Vehicle description
- Maintenance
- Power unit
- Engine repair
- Turbocharging
- Exhaust system
- Cooling system
- Ignition system
- Fuel system
- Motronic injection system
- MPI and MPFI injection system
- Transmission
- Clutch
- Gearbox and shafts
- Chassis
- Steering
- Car suspension
- Brake system
- Wheels and tires
- Body
- Heating and ventilation
- Body parts
- Electrical equipment
- Fuses and relays
- Power devices
- Lighting and lamps
- Tools and devices
- Electrical circuits