Car manual transmission Audi A6 C4
The gearbox is fixed at the rear of the engine and has five forward gears and one reverse gear, a synchronization mechanism is installed in all forward and reverse gears. In the 012 gearbox, the gear lever is connected to the gearbox by one shift rod, and in the 01E gearbox by two shift rods.
Gear shift mechanism device
Gear Shift Mechanism 012 1. Handle 2. Bushing 3. Frame 4. Cover 5. Bolt 6. Bushing 7. Ring 8. Retaining ring 9. Spacer sleeve 10. Spring 11. Ball stop 12....
Gear Shift Mechanism 012 1. Handle 2. Bushing 3. Frame 4. Cover 5. Bolt 6. Bushing 7. Ring 8. Retaining ring 9. Spacer sleeve 10. Spring 11. Ball stop 12....
Technical characteristics of mechanical transmission
Gearbox type Five forward gears and one reverse gear stroke, synchronization mechanism on all forward and reverse gears. Lubricants Cm. subsection 3.1.1.2. or...
Gearbox type Five forward gears and one reverse gear stroke, synchronization mechanism on all forward and reverse gears. Lubricants Cm. subsection 3.1.1.2. or...
Adjusting the gear shift mechanism
Gearbox 012 1. Raise and support the front of the vehicle. 2. Set the gearshift lever to neutral. Remove the gearshift knob, frame and boot. 3. Remove the...
Gearbox 012 1. Raise and support the front of the vehicle. 2. Set the gearshift lever to neutral. Remove the gearshift knob, frame and boot. 3. Remove the...
Removal and installation of manual transmission
Removal 1. Raise and support the front of the vehicle. 2. Remove the lower engine panels. 3. Disconnect the negative battery cable. 4. Disconnect the wires...
Removal 1. Raise and support the front of the vehicle. 2. Remove the lower engine panels. 3. Disconnect the negative battery cable. 4. Disconnect the wires...
Multi-function switch and reversing light switch
Multifunctional switch (012) The switch is located on the top of the gearbox. Removal 1. Raise and support the front of the vehicle. 2. Disconnect the wire and...
Multifunctional switch (012) The switch is located on the top of the gearbox. Removal 1. Raise and support the front of the vehicle. 2. Disconnect the wire and...
Speedometer sensor
Speedometer sensor and multifunction switch connector 1 - speedometer sensor 2 - Multi-function switch connector The sensor is located on the left side of the...
Speedometer sensor and multifunction switch connector 1 - speedometer sensor 2 - Multi-function switch connector The sensor is located on the left side of the...
Replacing the seals of the manual transmission
Drive shaft seals 1. Raise and support the front of the vehicle. 2. Disconnect the shaft from the corresponding drive flange. 3. Unscrew the central bolt. 4....
Drive shaft seals 1. Raise and support the front of the vehicle. 2. Disconnect the shaft from the corresponding drive flange. 3. Unscrew the central bolt. 4....
Visual repair of gearbox 012
Gearbox 012 complete 1. Tapered roller bearing 2. Reverse gear 3. 5th gear pinion 4. 4th gear pinion 5. 3rd gear pinion 6. 2nd gear pinion 7. 1st gear pinion...
Gearbox 012 complete 1. Tapered roller bearing 2. Reverse gear 3. 5th gear pinion 4. 4th gear pinion 5. 3rd gear pinion 6. 2nd gear pinion 7. 1st gear pinion...
This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian
Similar sections of other Audi car models:
General information: User manual Audi 80 B3 (1986-1991, petrol)
General information: User manual Audi 100 C4 (1990-1994)
Transmission: Manual transmission Audi A3 Type 8L (1996-2003)
General information: Operating instructions Audi A4 B7 (2004-2008)
General information: User manual Audi A8 D2 (1994-2002)
General information: User manual Audi Q5 Type 8R (2008-2017)
General information: User manual Audi 80 B3 (1986-1991, petrol)
General information: User manual Audi 100 C4 (1990-1994)
Transmission: Manual transmission Audi A3 Type 8L (1996-2003)
General information: Operating instructions Audi A4 B7 (2004-2008)
General information: User manual Audi A8 D2 (1994-2002)
General information: User manual Audi Q5 Type 8R (2008-2017)
Share information:
- General information
- User manual
- Maintenance
- Troubleshooting
- Power unit
- V6 petrol engines
- V8 petrol engines
- Diesel engines
- Cooling and heating system
- Injection system (gasoline)
- Fuel system (diesel)
- Supply system
- Exhaust system
- Ignition system
- Transmission
- Clutch
- Mechanical gearbox
- Automatic gearbox
- Chassis
- Brake system
- Car suspension
- Steering
- Body
- Body elements
- Doors, locks and windows
- Electrical equipment
- Equipment and devices
- Power devices
- Electrical circuits
- Schemes (petrol engine 2.7 l)
- Schemes (petrol engine 4.2 l)
- Schemes (diesel engine 2.5 l)
- General information
- User manual
- Maintenance
- Power unit
- Engine repair
- Cooling system
- Fuel system
- Engine management
- Fuel system (diesel)
- Exhaust system
- Transmission
- Clutch
- Car gearbox
- Chassis
- Front suspension
- Rear suspension
- Steering
- Wheels and tires
- Brake system
- Body
- Exterior
- Interior
- Electrical equipment
- Air conditioner
- Equipment and devices
- Electrical circuits
- General information
- User manual
- Maintenance (gasoline)
- Maintenance (Diesel)
- Gasoline engines
- 4 cylinder engines
- 5 cylinder engines
- 6 cylinder engines
- Diesel engines
- 4 cylinder engines
- 5 cylinder engines
- Engine repair
- Removal and reassembly
- Cooling system
- Single point injection system
- Multipoint injection system
- MPI/MPFI injection system
- Fuel system (diesel)
- Exhaust system
- Ignition system
- Transmission
- Clutch
- Manual transmission
- Automatic transmission
- Drive shafts
- Chassis
- Brake system
- Front suspension
- Rear suspension
- Steering
- Body
- Exterior (external elements)
- Interior (internal elements)
- Electrical equipment
- Power devices
- Lighting and appliances
- Electrical circuits